MSDS Delta THENE 40 - Cosella-Dörken Products, Inc

<strong>Cosella</strong>-Dörken <strong>Products</strong> <strong>Inc</strong>.4655 <strong>Delta</strong> Way, Beamsville, Ontario L0R 1B4Tel. (905) 563-3255 Fax: (905) 563-5582Issue Date: March 8, 2011Section I—Product InformationMaterial Safety Data SheetProduct Name DELTA ® -<strong>THENE</strong> 60 and DELTA ® -<strong>THENE</strong> <strong>40</strong>Product TypeSBS rubberized asphalt laminated to white HDPEProduct UseSelf-Adhesive Waterproofing MembraneSection II—Hazardous Ingredients/Identity InformationHazardous Components (Specific Chemical Identity, Common Name(s))Other LimitsOSHA PEL CAS Number Recommended % of total weightAsphalt, petroleum 8052-45-4 60-80Polymer 9003-55-8 5-20Inert ingredientsThis product contains asphalt. Some asphalt contains sulfur compounds which may form hydrogen sulfide when heated orburned. At higher concentrations (above 10 ppm), hydrogen sulfide is extremely toxic by inhalation, may cause respiratorytractirritation and respiratory failure, comma and death. Direct skin and eye contact may cause irritation.Hazards IdentificationsPrimary Routes(s) Of Entry Inhalation – possible if product becomes, but considered unlikely.Eve HazardsParticles may cause eye irritation.Skin HazardsMay cause skin irritation and contact dermatitis upon prolonged contact.Ingestion HazardsNot a probable route of exposure.Inhalation HazardsNot a probable route of exposure under normal conditions of useSection III—Physical/Chemical CharacteristicsAppearance Flexible sheet Vapor Pressure Not applicableChemical Type Mixture Vapor Density Not applicablePhysical State Solid pH Factor Not applicableBoiling Point343-538°C SolubilityNot applicable650-1000°FSpecific Gravity >1.0 Evaporation Rate Not applicablePercent Volatiles

Section VI—Toxicological PropertiesChronic/CarcinogenicityNon of the ingredients present in the product, at concentrations equal to orgreater than 0.1% have been determined to be carcinogenic by IARC, NTP,OSHA, or ACGIH.Miscellaneous Toxicological InformationToxicological testing has not been conducted for this product overall.Available toxicological data for individual ingredients are summarized below.Section VII—First Aid MeasuresEye In case of contact, hold eyelids apart and immediately flush eyes with plenty of water for at least 15minutes. Get medical attention immediately if irritation develops and persists.SkinRemove contaminated clothing and shoes. Wash affected areas with soap and water.IngestionInhalationSection VIII—Preventative MeasuresEngineering ControlsPersonal Protective EquipmentGet medical attention immediately. DO NOT INDUCE VOMITING. Never give anything by mouth to anunconscious victim.Remove the person from the contaminated area to fresh air. If breathing is difficult, give oxygen. If notbreathing, give artificial respiration. Get medical attention immediately.Use with adequate general and local exhaust ventilationRespiratory Protection: None normally required. Respiratory use may be required dueto secondary operations such as cutting, sanding, buffing, etc. The level of respiratoryprotection needed should be based on the evaluation of chemical exposures by ahealth or safety professional.Skin Protection: Use with protective gloves and apron to prevent skin contact.Eye / Face Protection: Safety glasses with side shields recommended.Occupational Exposure Limits for individual ingredients (if available) are listed below.Asphalt fumeACCGIH TLV-TWA 0.5 mg/m 3 (inhalable fraction and vapor)Ingredient(s) – Exposure LimitsOSHA PEL-TWA 5 mg/m 3ACGIH TLV-TWA 0.5 mg/m 3 (Benzene soluble aerosol)Section IX—Handling and StorageHandling and StorageRequirementsSection X—Disposal and TransportationDisposalTransport InformationGroundIMDGIATASection XI—Regulatory InformationU.S. Regulatory InformationIngredient(s) – StateRegulationsCanadian RegulatoryInformationKeep containers tightly close. Store in a cool, dry, well-ventilated area. Protected fromheat sparks, or flame. Use only with adequate ventilation.Disposal In accordance with applicable federal, state and local government regulations.Not restrictedNot restrictedNot restrictedAsphalt may contain detectable amounts of chemicals known to the State of Californiato cause cancer or reproductive harm.Asphalt, petroleumCalifornia – Proposition 65This product has been classified in accordance with the hazard criteria of the CPR andthe <strong>MSDS</strong> contains all the information required by the CPR.WHMIS Classification: Not classified or controlled.The data and information is based on our knowledge to date and is intended to describe the product with regard to safetyrequirements. They are not to be interpreted as a specification of properties of the products described.